Journal of Ultrafine Grained and Nanostructured Materials

Journal of Ultrafine Grained and Nanostructured Materials

Green Synthesis and Characterization of Cu0.5Zn0.5FeAlO4 Magnetic Nanoparticles with Enhanced Photocatalytic Activity

Document Type : Research Paper

Authors
Husam Abdulhussein Radhi Alzuabidi
Ali Naghipour
Saeid Taghavi Fardood
Department of Chemistry, Ilam University
10.22059/jufgnsm.2024.02.06
Abstract
Water pollution poses a significant global challenge, with toxic and carcinogenic dyes in wastewater threatening human health. Developing efficient and reusable photocatalysts is essential for advanced and sustainable water treatment solutions. In this project, Magnetic Cu0.5Zn0.5FeAlO4 nanoparticles were prepared through an eco-friendly method utilizing tragacanth gel as a stabilizing agent. The resulting nanoparticles were characterized using XRD, BET, FESEM, UV–Vis-DRS, TEM, EDX, Mapping and VSM techniques. The XRD pattern confirms the presence of the cubic spinel crystal structure in the Cu0.5Zn0.5FeAlO4 MNPs, with an average crystallite size of 12 nm. The TEM image showed an average particle size of 25–30 nm. The EDX and mapping analysis reveal all elemental compositions in Cu0.5Zn0.5FeAlO4 MNPs, indicating a pure phase. The band gap was determined from UV–vis DRS spectra by using the tauc equation and it was found to be of about 1.95 ev. The VSM analysis demonstrated superparamagnetic properties with a saturation magnetization value of approximately 3.74 emu/g. The Cu0.5Zn0.5FeAlO4 MNPs exhibited efficient photodegradation of reactive blue 222 dye when under visible light. The sample was easily recovered and reused due to the magnetic properties of the nanoparticles. This showed excellent catalytic efficiency, maintaining strong performance for up to four cycles with very little loss in activity.
Keywords
Green synthesis
Magnetic naoparticles
Reactive blue 222 degradation
Photocatalysis
  1. Kumari H, Sonia, Suman, Ranga R, Chahal S, Devi S, Sharma S, Kumar S, Kumar P, and Kumar S, A review on photocatalysis used for wastewater treatment: dye degradation. Water, Air, & Soil Pollution. 2023;234:349.
  2. Al Taee MB and Al Shabander BM, Study the Effect of ZnO Concentrations on The Photocatalytic Activity of TiO2/Cement Nanocomposites. Chemical Methodologies. 2022;6:831-841.
  3. AbouSeada N, Ahmed MA, and Elmahgary MG, Synthesis and characterization of novel magnetic nanoparticles for photocatalytic degradation of indigo carmine dye. Materials Science for Energy Technologies. 2022;5:116-124.
  4. Saadati A and Sheibani S, Photocatalytic performance of SnS2 nanoflakes synthesized through a facile reflux method. Journal of Ultrafine Grained and Nanostructured Materials. 2023;56:129-136.
  5. Hadi E and Jasim KK, Responsive UV-light Photocatalytic of Ag/ZnO Nanocomposites for Removal of Brilliant Blue Dye: As a Model for Advanced Chemical Studies. Advanced Journal of Chemistry, Section A. 2024;604-614.
  6. Moalej NS, Ahadi S, and Sheibani S, Photocatalytic degradation of methylene blue by 2 wt.% Fe doped TiO2 nanopowder under visible light irradiation. Journal of Ultrafine Grained and Nanostructured Materials. 2019;52:133-141.
  7. Arjomandi Rad F and Talat Mehrabad J, Exploring the Photocatalytic Activity of Magnesium and Copper-Doped Titanium Dioxide Nano Catalyst through Synthesis and Characterization. Advanced Journal of Chemistry, Section A. 2024;7:374-385.
  8. Vishnu G, Singh S, Naik TSK, Viswanath R, Ramamurthy PC, Bhadrecha P, Naik HB, Singh J, Khan NA, and Zahmatkesh S, Photodegradation of methylene blue dye using light driven photocatalyst-green cobalt doped cadmium ferrite nanoparticles as antibacterial agents. Journal of Cleaner Production. 2023;404:136977.
  9. Taghavi Fardood S, Moradnia F, and Aminabhavi TM, Green synthesis of novel Zn0.5Ni0.5FeCrO4 spinel magnetic nanoparticles: Photodegradation of 4-nitrophenol and aniline under visible light irradiation. Environmental Pollution. 2024;358:124534.
  10. Gumma S, Puthalapattu RP, Punyasamudram S, Kanuparthy PR, and Putta Venkata NK, Eco-Friendly Phytochemical-Derived Co₃O₄@Ag Nanoparticles for Ethanol Oxidation and Antibacterial Activity. Asian Journal of Green Chemistry. 2024;8:560-578.
  11. Hakimi M, Hosseini HA, and Elhaminezhad B, Fabrication of Manganese Dioxide Nanoparticles in Starch and Gelatin Beds: Investigation of Photocatalytic Activity. Chemical Methodologies. 2023;8:37-46.
  12. Chala GH, Review on Green Synthesis of Iron-Based Nanoparticles for Environmental Applications. Journal of Chemical Reviews. 2023;5:1-14.
  13. Jalali N, Nami M, Rashchi F, and Rakhsha A, Photocatalytic properties of ZnO/CuO nanocomposite prepared in acidic media. Journal of Ultrafine Grained and Nanostructured Materials. 2022;55:21-30.
  14. Taghavi Fardood S, Moradnia F, Yekke Zare F, Heidarzadeh S, Azad Majedi M, Ramazani A, Sillanpää M, and Nguyen K, Green synthesis and characterization of α-Mn2O3 nanoparticles for antibacterial activity and efficient visible-light photocatalysis. Scientific reports. 2024;14:6755.
  15. Ansari F, Sheibani S, Caudillo-Flores U, and Fernández-García M, Effect of calcination process on the gas phase photodegradation by CuO-Cu2O/TiO2 nanocomposite photocatalyst. Journal of Ultrafine Grained and Nanostructured Materials. 2020;53:23-30.
  16. Scaria SS and Sebastian JK, Novel biocompatible zinc oxide nanoparticle synthesis using Quassia indica leaf extract and evaluation of its photocatalytic, antimicrobial, and cytotoxic potentials. Biomass Conversion and Biorefinery. 2023;1-20.
  17. Bashar MA, Molla MTH, Chandra D, Malitha MD, Islam MS, Rahman MS, and Ahsan MS, Hydrothermal synthesis of cobalt substitute zinc-ferrite (Co1-xZnxFe2O4) nanodot, functionalised by polyaniline with enhanced photocatalytic activity under visible light irradiation. Heliyon. 2023;9:
  18. Mohamed A, Mahanna H, and Samy M, Synergistic effects of photocatalysis-periodate activation system for the degradation of emerging pollutants using GO/MgO nanohybrid. Journal of Environmental Chemical Engineering. 2024;12:112248.
  19. Singh S, Atri AK, Qadir I, Sharma S, Manhas U, and Singh D, Role of different fuels and sintering temperatures in the structural, optical, magnetic, and photocatalytic properties of chromium-containing nickel ferrite: kinetic study of photocatalytic degradation of rhodamine B dye. ACS Omega. 2023;8:6302-6317.
  20. Singh J, Kumari P, and Basu S, Degradation of toxic industrial dyes using SnO2/g-C3N4 nanocomposites: Role of mass ratio on photocatalytic activity. Journal of Photochemistry and Photobiology A: Chemistry. 2019;371:136-143.
  21. Sarmah S, Patra K, Maji P, Ravi S, and Bora T, A comparative study on the structural, magnetic and dielectric properties of magnesium substituted cobalt ferrites. Ceramics International. 2023;49:1444-1463.
  22. Ahmad I, Abbas T, Ziya AB, Abbas G, and Maqsood A, Size dependent structural and magnetic properties of Al substituted Co–Mg ferrites synthesized by the sol–gel auto-combustion method. Materials Research Bulletin. 2014;52:11-14.
  23. Okba EA, Fakhry FE, El-Bahnasawy HH, Abdel-Galeil MM, and El Shater RE, Development of heterogeneous photocatalysis delafossite structured Ag doped Cd-Cu ferrite spinel nanoparticles for an efficient photodegradation process. Journal of Photochemistry and Photobiology A: Chemistry. 2024;448:115275.
  24. Harki DAH, Naghipour A, and Taghavi Fardood S, Eco-Friendly Synthesis and Characterization of Mg0.5Co0.5Fe2O4 Magnetic Nanoparticles for Photocatalytic Degradation of Congo Red Dye. Case Studies in Chemical and Environmental Engineering. 2024;10:101016.
  25. Shafiq K, Aadil M, Hassan W, Choudhry Q, Gul S, Rais A, Fattah AA, Mahmoud KH, and Ansari MZ, Cobalt and holmium co-doped nickel ferrite nanoparticles: synthesis, characterization and photocatalytic application studies. Zeitschrift fur Physikalische Chemie. 2023;237:1325-1344.
  26. Sarifuddin WS, Mahadi AH, Hussin MR, Masri MKZ, Prasetyoko D, and Bahruji H, Cu doped ZnFe2O4 photocatalysts for enhanced hydrogen production and dye degradation in the visible region. Journal of Photochemistry and Photobiology A: Chemistry. 2024;453:115658.
  27. Singhal S, Barthwal SK, and Chandra K, Structural, magnetic and Mössbauer spectral studies of nanosize aluminum substituted nickel zinc ferrites. Journal of Magnetism and Magnetic Materials. 2006;296:94-103.
  28. Henderson CMB, Charnock JM, and Plant DA, Cation occupancies in Mg, Co, Ni, Zn, Al ferrite spinels: a multi-element EXAFS study. Journal of Physics: Condensed Matter. 2007;19:076214.
  29. Yasar M and Kadhem AA, Investigating the Role of Aluminum Doping on the Bandgap Modulation and Photocatalytic Efficiency of Strontium Nickel Ferrites for Ciprofloxacin Degradation. Arabian Journal for Science and Engineering. 2024;1-15.
  30. Yasar M, Nazir R, and Noreen F, Synthesis, characterization, and photocatalytic activity of aluminum-doped nickel manganese ferrite for the photodegradation of methylene blue. Reaction Kinetics, Mechanisms and Catalysis. 2024;137:505-521.
  31. Ramadevi P, Shanmugavadivu R, Venkatesan R, Mayandi J, and Sagadevan S, Photocatalytic dye degradation efficiency and reusability of aluminium substituted nickel ferrite nanostructures for wastewater remediation. Inorganic Chemistry Communications. 2023;150:110532.
  32. Abidin MZU, Ikram M, Moeen S, Nazir G, Kanoun MB, and Goumri-Said S, A comprehensive review on the synthesis of ferrite nanomaterials via bottom-up and top-down approaches advantages, disadvantages, characterizations and computational insights. Coordination Chemistry Reviews. 2024;520:216158.
  33. Dichayal S, Murade V, Deshmukh S, Pansambal S, Hase D, and Oza R, Green Synthesis of Cobalt Ferrite Nanoparticles: A Comprehensive Review on Eco-friendly Approaches, Characterization Techniques, and Potential Applications. Journal of Chemical Reviews. 2024.
  34. Slimani Y and Hannachi E, Synthesis of ferrite nanoparticles using sonochemical methods, in Ferrite Nanostructured Magnetic Materials. 2023, Elsevier. p. 121-147.
  35. Tamboli QY, Patange SM, Mohanta YK, Sharma R, and Zakde KR, Green synthesis of cobalt ferrite nanoparticles: An emerging material for environmental and biomedical applications. Journal of Nanomaterials. 2023;2023:9770212.
  36. Kurian M, Green synthesis routes for spinel ferrite nanoparticles: a short review on the recent trends. Journal of the Australian Ceramic Society. 2023;59:1161-1175.
  37. Fiaz S, Ahmed MN, ul Haq I, Shah SWA, and Waseem M, Green synthesis of cobalt ferrite and Mn doped cobalt ferrite nanoparticles: Anticancer, antidiabetic and antibacterial studies. Journal of Trace Elements in Medicine and Biology. 2023;80:127292.
  38. Sherin A, Munir R, Mushtaq N, Muneer A, Ambreen H, Younas F, Farah MA, Elsadek MF, and Noreen S, Reactive Blue MEBF 222 dye and textile wastewater treatment using metal-doped cobalt and nickel perovskites by batch and column adsorption process. Environmental Monitoring and Assessment. 2024;196:927.
  39. Kiani MT, Ramazani A, and Taghavi Fardood S, Green synthesis and characterization of Ni0.25Zn0.75Fe2O4 magnetic nanoparticles and study of their photocatalytic activity in the degradation of aniline. Applied Organometallic Chemistry. 2023;37:e7053.
  40. Ahankar H, Taghavi Fardood S, and Ramazani A, One-pot three-component synthesis of tetrahydrobenzo[b]pyrans in the presence of Ni0.5Cu0.5Fe2O4 magnetic nanoparticles under microwave irradiation in solvent-free conditions. Iranian Journal OF Catalysis. 2020;10:195-201.
  41. Kiani MT, Ramazani A, Rahmani S, and Taghavi Fardood S, Green synthesis and characterisation of superparamagnetic Cu0.25Zn0.75Fe2O4 nanoparticles and investigation of their photocatalytic activity. International Journal of Environmental Analytical Chemistry. 2024;104:2895-2911.
  42. Taghavi Fardood S, Moradnia F, Forootan R, Abbassi R, Jalalifar S, Ramazani A, and Sillanpӓӓ M, Facile green synthesis, characterization and visible light photocatalytic activity of MgFe2O4@CoCr2O4 magnetic nanocomposite. Journal of Photochemistry and Photobiology A: Chemistry. 2022;423:113621.
  43. Taghavi Fardood S, Ganjkhanlu S, Moradnia F, and Ramazani A, Green synthesis, characterization, and photocatalytic activity of superparamagnetic MgFe2O4@ZnAl2O4 nanocomposites. Scientific reports. 2024;14:16670.
  44. Das GS, Shim JP, Bhatnagar A, Tripathi KM, and Kim T, Biomass-derived Carbon Quantum Dots for Visible-Light-Induced Photocatalysis and Label-Free Detection of Fe(III) and Ascorbic acid. Scientific reports. 2019;9:15084.
  45. Zheng X, Yuan J, Shen J, Liang J, Che J, Tang B, He G, and Chen H, A carnation-like rGO/Bi2O2CO3/BiOCl composite: efficient photocatalyst for the degradation of ciprofloxacin. Journal of Materials Science: Materials in Electronics. 2019;30:5986-5994.
  46. Gouvêa CAK, Wypych F, Moraes SG, Durán N, Nagata N, and Peralta-Zamora P, Semiconductor-assisted photocatalytic degradation of reactive dyes in aqueous solution. Chemosphere. 2000;40:433-440.
  47. Habibi MH and Mosavi V, Synthesis and characterization of Fe2O3/Mn2O3/FeMn2O4 nano composite alloy coated glass for photo-catalytic degradation of Reactive Blue 222. Journal of Materials Science: Materials in Electronics. 2017;28:11078-11083.
  48. Barkaat S, Zuber M, Zia KM, Noreen A, and Tabasum S, UV/H2O2/Ferrioxalate Based Integrated Approach to Decolorize and Mineralize Reactive Blue Dye: Optimization Through Response Surface Methodology. Zeitschrift fur Physikalische Chemie. 2021;235:525-547.
  49. Li Z, Kang W, Han Z, Yan J, Cheng B, and Liu Y, Hierarchical MnOx@PVDF/MWCNTs tree-like nanofiber membrane with high catalytic oxidation activity. Journal of Alloys and Compounds. 2019;780:805-815.
  50. Yaghoubi A, Ramazani A, and Taghavi Fardood S, Synthesis of Al2O3/ZrO2 Nanocomposite and the Study of Its effects on Photocatalytic Degradation of Reactive Blue 222 and Reactive Yellow 145 Dyes. ChemistrySelect. 2020;5:9966-9973.
  51. Shojaei Yeganeh M, Kazemizadeh AR, Ramazani A, Eskandari P, and Rabbi Angourani H, Plant-mediated synthesis of Cu0.5Zn0.5Fe2O4 nanoparticles using Minidium leavigatum and their applications as an adsorbent for removal of reactive blue 222 dye. Materials Research Express. 2019;6:1250f1254.
Journal of Ultrafine Grained and Nanostructured Materials
Volume 57, Issue 2
December 2024
Pages 158-167

  • Receive Date 02 December 2024
  • Revise Date 12 December 2024
  • Accept Date 15 December 2024