Journal of Ultrafine Grained and Nanostructured Materials

Journal of Ultrafine Grained and Nanostructured Materials

Photocatalytic degradation of methylene blue by 2 wt.% Fe doped TiO2 nanopowder under visible light irradiation

Document Type : Research Paper

Authors
Nikta S. Moalej 1
Sina Ahadi 1
Saeed Sheibani 2
1 School of Metallurgy and Materials Engineering, College of Engineering, University of Tehran, Tehran, Iran.
2 University of Tehran
10.22059/jufgnsm.2019.02.01
Abstract
In this paper, 2wt.% Fe doped TiO2 nanopowder was prepared by a combination of sol-gel and mechanical alloying methods. The mechanical alloying of Fe powder with Ti(OH)4 gel produced from the sol-gel method was used to produce Fe doped TiO2 nanopowder. The synthesized samples were characterized by X-ray diffraction (XRD), field emission scanning electron microscopy (FESEM) and diffuse reflectance spectroscopy (DRS). The photocatalytic behavior of nanopowder was examined by the degradation of methylene blue (MB) under visible light irradiation. XRD result showed that the phase structure was a combination of anatase and rutile phases and the anatase percentage was considerably increased to 72.3 % by Fe doping. The FESEM results demonstrated that the average particle size of TiO2 was decreased to 45 nm by Fe doping through ball milling. DRS results indicated the band gap of photocatalyst has shifted from 2.95 to 2.60 eV by Fe doping through ball milling. Photodegradation of MB was evaluated and the degradation rate was reached to 47% after 240 min under visible light irradiation. The photocatalytic performance of TiO2 nanoparticles improved by doping Fe through mechanical milling. Degradation reaction conformed by the first-order reaction kinetic model. The recycled Fe doped TiO2 nano-photocatalyst showed only a slight decrease of 7% in degradation rate after the third cycle.
Keywords
TiO2
Nano-photocatalyst
Doping
Sol-Gel
Mechanical Milling
1. Lee B-N, Liaw W-D, Lou J-C. Photocatalytic Decolorization of Methylene Blue in Aqueous TiO2 Suspension. Environmental Engineering Science. 1999;16(3):165-75.
2. Salehi M, Hashemipour H, Mirzaee M. Experimental Study of Influencing Factors and Kinetics in Catalytic Removal of Methylene Blue with TiO2 Nanopowder. American Journal of Environmental Engineering. 2012;2(1):1-7.
3. Wu C-H, Chern J-M. Kinetics of Photocatalytic Decomposition of Methylene Blue. Industrial & Engineering Chemistry Research. 2006;45(19):6450-7.
4. Tae Kwon Y, Yong Song K, In Lee W, Jin Choi G, Rag Do Y. Photocatalytic Behavior of WO3-Loaded TiO2 in an Oxidation Reaction. Journal of Catalysis. 2000;191(1):192-9.
5. Tang WZ, Huren A. UV/TiO2 photocatalytic oxidation of commercial dyes in aqueous solutions. Chemosphere. 1995;31(9):4157-70.
6. Nagaveni K, Sivalingam G, Hegde MS, Madras G. Photocatalytic Degradation of Organic Compounds over Combustion-Synthesized Nano-TiO2. Environmental Science & Technology. 2004;38(5):1600-4.
7. Nasralla N, Yeganeh M, Astuti Y, Piticharoenphun S, Shahtahmasebi N, Kompany A, et al. Structural and spectroscopic study of Fe-doped TiO2 nanoparticles prepared by sol–gel method. Scientia Iranica. 2013;20(3):1018-22.
8. Jang HD, Kim S-K, Kim S-J. Effect of particle size and phase composition of titanium dioxide nanoparticles on the photocatalytic properties. Journal of Nanoparticle Research. 2001;3(2-3):141-7.
9. Abazović ND, Mirenghi L, Janković IA, Bibić N, Šojić DV, Abramović BF, et al. Synthesis and Characterization of Rutile TiO2 Nanopowders Doped with Iron Ions. Nanoscale Research Letters. 2009;4(6):518-25.
10. Park HS, Kim DH, Kim SJ, Lee KS. The photocatalytic activity of 2.5wt% Cu-doped TiO2 nano powders synthesized by mechanical alloying. Journal of Alloys and Compounds. 2006;415(1-2):51-5.
11. Lei XF, Xue XX, Yang H. Preparation and characterization of Ag-doped TiO2 nanomaterials and their photocatalytic reduction of Cr(VI) under visible light. Applied Surface Science. 2014;321:396-403.
12. Selvam K, Swaminathan M. Au-doped TiO2 nanoparticles for selective photocatalytic synthesis of quinaldines from anilines in ethanol. Tetrahedron Letters. 2010;51(37):4911-4.
13. Marami MB, Farahmandjou M, Khoshnevisan B. Sol–Gel Synthesis of Fe-Doped TiO2 Nanocrystals. Journal of Electronic Materials. 2018;47(7):3741-8.
14. Al-Jawad SMH, Taha AA, Salim MM. Synthesis and characterization of pure and Fe doped TiO2 thin films for antimicrobial activity. Optik. 2017;142:42-53.
15. Sánchez LC, Calle AM, Arboleda JD, Beltran JJ, Barrero CA, Osorio J, et al. Fe-doped TiO2 prepared by mechanical alloying. ICAME 2007: Springer Berlin Heidelberg; 2008. p. 289-94.
16. Effendi M. Effect of doping Fe on TiO2 thin films prepared by spin coating method. 2012.
17. Eadi SB, Kim S, Jeong SW, Jeon HW. Novel Preparation of Fe Doped TiO2 Nanoparticles and Their Application for Gas Sensor and Photocatalytic Degradation. Advances in Materials Science and Engineering. 2017;2017:1-6.
18. Zhu S, Liu W, Wei S, Fan C, Li Y. Local Structure around Iron Ions in Anatase TiO2.  AIP Conference Proceedings: AIP; 2007.
19. Jenkins R, Snyder RL. Introduction to X-ray Powder Diffractometry. John Wiley & Sons, Inc.; 1996.
20. Lipson H, Steeple H. Interpretation of X-ray powder diffraction patterns: Macmillan; 1970.
21. Ingle JD, Crouch SR. Signal-to-noise ratio considerations. Spectrochemical Analysis Prentice Hall, Englewood Cliffs, NJ. 1988:135-63.
22. Spurr RA, Myers H. Quantitative Analysis of Anatase-Rutile Mixtures with an X-Ray Diffractometer. Analytical Chemistry. 1957;29(5):760-2.
23. Rino J-P, Studart N. Structural correlations in titanium dioxide. Physical Review B. 1999;59(10):6643-9.
24. Liqiang J, Xiaojun S, Baifu X, Baiqi W, Weimin C, Honggang F. The preparation and characterization of La doped TiO2 nanoparticles and their photocatalytic activity. Journal of Solid State Chemistry. 2004;177(10):3375-82.
25. Ali T, Tripathi P, Azam A, Raza W, Ahmed AS, Ahmed A, et al. Photocatalytic performance of Fe-doped TiO2nanoparticles under visible-light irradiation. Materials Research Express. 2017;4(1):015022.
26. Choi J, Park H, Hoffmann MR. Effects of Single Metal-Ion Doping on the Visible-Light Photoreactivity of TiO2. The Journal of Physical Chemistry C. 2009;114(2):783-92.
27. Ward TS, Chen W, Schoenitz M, Dave RN, Dreizin EL. A study of mechanical alloying processes using reactive milling and discrete element modeling. Acta Materialia. 2005;53(10):2909-18.
28. Carneiro JO, Azevedo S, Fernandes F, Freitas E, Pereira M, Tavares CJ, et al. Synthesis of iron-doped TiO2 nanoparticles by ball-milling process: the influence of process parameters on the structural, optical, magnetic, and photocatalytic properties. Journal of Materials Science. 2014;49(21):7476-88.
29. Gomathi Devi L, Kottam N, Girish Kumar S, Eraiah Rajashekhar K. Preparation, characterization and enhanced photocatalytic activity of Ni2+ doped titania under solar light. Open Chemistry. 2010;8(1).
30. Asiltürk M, Sayılkan F, Arpaç E. Effect of Fe3+ ion doping to TiO2 on the photocatalytic degradation of Malachite Green dye under UV and vis-irradiation. Journal of Photochemistry and Photobiology A: Chemistry. 2009;203(1):64-71.
31.  Ali T, Tripathi P, Azam A, Raza W, Ahmed AS, Ahmed A, et al. Photocatalytic performance of Fe-doped TiO2 nanoparticles under visible-light irradiation. Materials Research Express. 2017;4(1):015022.
32. Tauc J, Grigorovici R, Vancu A. Optical Properties and Electronic Structure of Amorphous Germanium. physica status solidi (b). 1966;15(2):627-37.
33. Samsudin EM, Abd Hamid SB. Effect of band gap engineering in anionic-doped TiO 2 photocatalyst. Applied Surface Science. 2017;391:326-36.
34. Rauf MA, Meetani MA, Hisaindee S. An overview on the photocatalytic degradation of azo dyes in the presence of TiO2 doped with selective transition metals. Desalination. 2011;276(1-3):13-27.
35. Kemp TJ, McIntyre RA. Transition metal-doped titanium(IV) dioxide: Characterisation and influence on photodegradation of poly(vinyl chloride). Polymer Degradation and Stability. 2006;91(1):165-94.
36. Brus LE. Electron–electron and electron‐hole interactions in small semiconductor crystallites: The size dependence of the lowest excited electronic state. The Journal of Chemical Physics. 1984;80(9):4403-9.
37. Brus L. Electronic wave functions in semiconductor clusters: experiment and theory. The Journal of Physical Chemistry. 1986;90(12):2555-60.
38. Li Q, Liang W, Ku Shang J. Enhanced visible-light absorption from PdO nanoparticles in nitrogen-doped titanium oxide thin films. Applied Physics Letters. 2007;90(6):063109.
39. Mahmoodi NM, Arami M, Limaee NY, Tabrizi NS. Kinetics of heterogeneous photocatalytic degradation of reactive dyes in an immobilized TiO2 photocatalytic reactor. Journal of Colloid and Interface Science. 2006;295(1):159-64.
40. Shafei A, Salarpour ME, Sheibani S. Effect of intermediate ball milling on the synthesis of Cu-doped TiO2 nano-photocatalyst by sol–gel method. Journal of Sol-Gel Science and Technology. 2019;92(1):173-85.
Journal of Ultrafine Grained and Nanostructured Materials
Volume 52, Issue 2
December 2019
Pages 133-141

  • Receive Date 09 October 2019
  • Revise Date 29 November 2019
  • Accept Date 29 November 2019